BAR 007
The BAR 007 was a Formula One car developed and raced by British American Racing (BAR) in technical partnership with Honda for the 2005 FIA Formula One World Championship season.[1][2] Featuring a carbon fiber monocoque chassis and powered by the Honda RA005E 3.0-litre V10 engine producing over 900 horsepower at more than 18,500 rpm, the car was driven by Jenson Button of the United Kingdom and Takuma Sato of Japan.[1][3] The design incorporated revised aerodynamics and engineering advances for improved performance, evolving from the preceding BAR 006 model with a more compact structure.[2][3] The BAR 007's season was marked by a significant controversy at the San Marino Grand Prix, where both entries were disqualified after scrutineering revealed the cars fell below the 605 kg minimum weight limit due to a secondary fuel tank that permitted operation without fully filling the primary tank, effectively using fuel as adjustable ballast in violation of FIA technical regulations.[4][1] This infraction prompted the FIA to exclude the team from the race results and impose a two-race ban for the Spanish and Monaco Grands Prix following an unsuccessful appeal.[5][1] Upon resuming competition, the team demonstrated competitive pace, with Button securing two third-place finishes at the Canadian and United States Grands Prix, marking his first podiums of the season.[6] These results contributed to BAR-Honda accumulating 38 points and finishing sixth in the Constructors' Championship standings.[7] The 007 designation evoked James Bond's codename, aligning with the team's Lucky Strike sponsorship imagery, though the car ultimately represented BAR's final entry before Honda's full acquisition of the team.[2]Development and Design
Project Origins and Team Context
The BAR 007 project originated in the aftermath of British American Racing's (BAR) competitive 2004 Formula One season, during which the BAR 006 chassis helped the team secure second place in the Constructors' Championship with 88 points, trailing only Ferrari.[1] This performance prompted BAR to evolve the design into the 007, focusing on refinements to chassis, aerodynamics, and integration with Honda's RA005E V10 engine to pursue podium finishes and the team's first victory under updated 2005 regulations, including a two-race engine durability mandate and reduced V10 rev limits to 18,600 rpm.[3] Development emphasized weight reduction and compactness compared to the predecessor, with the chassis measuring approximately 5,240 mm in length and weighing the minimum 605 kg.[8] The BAR-Honda partnership, initiated with engine supply in 2000, deepened significantly ahead of 2005 when Honda acquired a 45% stake in the team in November 2004, signaling a shift toward greater Japanese involvement in design and operations while retaining BAR's British engineering base at Brackley.[9] This collaboration leveraged Honda's engine expertise—refined through prior F1 returns since 1983—and BAR's chassis development, with the 007 marking an intensified joint factory effort to challenge Renault and McLaren.[1] Key personnel included Chief Executive Officer Nick Fry, who oversaw strategic direction and sponsorship integration, and Technical Director Geoffrey Willis, responsible for aerodynamic and structural innovations drawing from wind tunnel data and computational fluid dynamics.[10] The team's driver lineup remained stable with Jenson Button as lead driver, entering his sixth season with BAR after consistent points-scoring in 2004, and Takuma Sato, retained for his Honda ties and aggressive style despite prior inconsistencies.[10] Test driver Anthony Davidson supported validation testing, contributing to pre-season shakedowns that confirmed reliability under new FIA homologation rules.[10] BAR's origins traced to 1999, evolving from the acquired Tyrrell team under British American Tobacco backing, but by 2005, the entity operated as a mature outfit with over 400 staff, bolstered by Michelin tyre partnership enhancements from winter tests.[2] The 007 was unveiled on January 16, 2005, at Barcelona's Circuit de Catalunya, underscoring the team's ambition amid rising expectations post-2004.[8]Chassis and Aerodynamic Innovations
The BAR 007 chassis was constructed from moulded carbon fibre and honeycomb composite monocoque, designed to exceed 2005 FIA impact and strength regulations while achieving significant weight reductions through tighter packaging and minimal carryover parts from the BAR 006.[3][2] Suspension utilized double wishbone setups front and rear, with pushrod-activated torsion springs, rockers, mechanical anti-roll bars, and Showa telescopic dampers, maintaining consistent wishbone geometry but incorporating larger monocoque clearances and a single lower wishbone keel for improved airflow management.[3][11] The design emphasized a lower center of gravity via compact engine integration, contributing to a visibly smaller overall footprint with dimensions of 4675 mm length, 1800 mm width, 3140 mm wheelbase, and undisclosed weight optimized for the 605 kg minimum.[1][2] Aerodynamic innovations adapted to 2005 FIA rules, including a 50 mm front wing height increase and elevated nose, with endplates contoured to match the nose's curvature for reduced drag.[3] The front wing profile featured heavily curved elements, a lowered regulatory-limit center section exploiting ground effects for augmented downforce, and a long-chord middle span with reduced camber to produce a cleaner wake, directed by advanced bargeboards with curved vanes, an additional flow-splitting vane, and sidepod fins.[11][1] Rear aerodynamics included a narrowed lower beam wing on dual thin struts augmented by a large gurney flap, while tightened sidepods enhanced rear downforce generation; the floor incorporated a "hammer head" section, and airbox/exhaust layouts centered airflow with wider central covers replacing chimney ducts for superior heat dissipation and efficiency.[11][3] These refinements, informed by unified BAR-Honda development, yielded a more integrated package over the BAR 006, prioritizing downforce and wake control ahead of rivals like Ferrari.[11][2]Engine Specifications and Powertrain
The BAR 007 featured the Honda RA005E engine, a 3.0-liter (2,998 cc) naturally aspirated V10 with a 90-degree cylinder bank angle, positioned mid-mounted in the chassis.[1][3] This engine complied with 2005 FIA regulations limiting revs to a maximum of 18,600 rpm and requiring a two-race lifespan per unit to enhance reliability and reduce costs.[1] Output was estimated at over 900 bhp (approximately 670 kW), with peak power achieved near the rev limit, though exact figures were not publicly disclosed by Honda due to competitive sensitivities.[3] The powertrain incorporated a Honda-Xtrac seven-speed sequential semi-automatic transmission with seamless shift technology, marking Honda's introduction of this system in Formula 1 for smoother gear changes without power interruption.[8][3] The gearbox featured a BAR-designed maincase housing Honda and Xtrac internals, hydraulic activation for gear selection, and a carbon plate clutch.[8] Rear-wheel drive was standard, with power delivered longitudinally through a limited-slip differential optimized for traction in varying track conditions.[12]| Component | Specification |
|---|---|
| Engine | Honda RA005E V10, 3.0 L, naturally aspirated, 90° V-angle |
| Displacement | 2,998 cc |
| Max RPM | 18,600 |
| Estimated Power | >900 bhp @ ~18,500 rpm |
| Transmission | 7-speed sequential semi-automatic, seamless shift |
| Gearbox Type | Longitudinal, hydraulic semi-automatic |
| Clutch | Carbon plate |
| Drive | Rear-wheel |
Sponsorship and Livery
Primary Sponsors and Financial Backing
 via its Lucky Strike brand, which served as the title sponsor, and Honda Motor Company, which provided engines and co-title partnership.[13][14] Lucky Strike branding dominated the car's livery, with the 555 variant—a fellow BAT tobacco brand—used in races prohibiting overt tobacco advertising, such as the Chinese Grand Prix on October 16, 2005.[15] Financial backing originated from BAT, which invested approximately £250 million over the team's first five years starting in 1999 to establish British American Racing as a constructor.[14] Honda augmented this support through engine supply and equity acquisition, purchasing a 45% stake in BAR-Honda on November 19, 2004, for an undisclosed sum amid team principal David Richards' departure.[16] By October 4, 2005, Honda completed full ownership by acquiring the remaining shares from BAT for around £17 million, transitioning the team toward Honda's independent factory effort in 2006 while BAT retained sponsorship through 2006.[17][13]Visual Design and Branding Evolution
The BAR 007 adopted a livery of predominantly silver bodywork accented with black elements, a scheme introduced in 2004 to obscure tobacco sponsorship branding amid regulatory restrictions on advertising.[18] This design prominently featured 555 logos, a codified reference to British American Tobacco's Lucky Strike brand, alongside red Honda emblems denoting the engine partnership.[19] The scheme maintained continuity from the BAR 006, prioritizing sponsor visibility while evading outright bans on cigarette promotion in certain markets.[18] Visually, the 007's chassis presented a more compact silhouette than its predecessor, with refined aerodynamics yielding a tighter, lower-profile form to enhance performance under updated 2005 regulations.[2][10] Key elements included a raised front wing endplate and modified sidepod inlets, adapting the livery's application to sleeker contours without altering core color motifs.[2] No substantive livery modifications occurred mid-season, preserving the established branding through races like the Canadian and Chinese Grands Prix.[20] This branding approach reflected BAR's strategic navigation of sponsorship dependencies, balancing visibility for 555 and Honda against evolving FIA tobacco curbs that had prompted the shift from overt red Lucky Strike schemes in prior years like 2003.[21] The consistent application underscored a focus on aerodynamic gains over aesthetic reinvention, aligning visual evolution with technical imperatives.[3]2005 Racing Season
Pre-Season Testing and Early Races
The BAR 007 was unveiled on 16 January 2005 at the Circuit de Catalunya in Barcelona, featuring a smaller and lighter chassis compared to its predecessor, the BAR 006.[8] Pre-season testing sessions, which began earlier with a concept car in November 2004, revealed inconsistent performance; the car suffered from reliability problems in some tests but demonstrated surprising speed in others.[22] [1] By mid-February, the team reported positive results during a session with updated aerodynamics and engine components aimed at meeting the season's two-race engine durability rules.[23] The pre-season program concluded with intensive testing at Valencia from 22 to 24 February 2005, spanning six weeks of development.[24] In the season-opening Australian Grand Prix on 6 March 2005 at Albert Park, Jenson Button qualified third but started from eighth due to a grid penalty; he ran as high as third before retiring on lap 57 of 58 with an engine failure, classified 11th after completing over 90% of the distance.[25] [26] Takuma Sato qualified 13th and finished 13th, outside the points-paying positions.[27] Button sustained rib and foot injuries in a practice crash, forcing him to miss the Malaysian Grand Prix on 20 March; test driver Anthony Davidson substituted in the #3 car but retired after two laps, while Sato also failed to finish.[28] At the Bahrain Grand Prix on 3 April 2005, Button retired on lap 46 with engine issues, and Sato crashed out on lap 27; both were unclassified.[29] BAR Honda scored no championship points across the first three races, underscoring persistent reliability challenges with the RA005E V10 engine despite promising testing pace and qualifying showings.[30] These early setbacks contrasted with the team's high expectations following a strong 2004 season, where they finished second in the constructors' standings.[1]Mid-Season Performance and Podium Finishes
Following the exclusion from the Spanish and Monaco Grands Prix, BAR-Honda returned with the 007 at the European Grand Prix at the Nürburgring on May 29, 2005, where Jenson Button qualified third but finished seventh after struggling with tire degradation during the race. Takuma Sato qualified 12th and retired on lap 41 due to hydraulic failure. In the Canadian Grand Prix on June 12, Button secured pole position—his first of the season—and converted it to a fourth-place finish, earning 6 points, while Sato ended eighth for 1 point. The team maintained momentum through the summer races, with Button consistently finishing in the points: fifth in the United States Grand Prix on June 19 (amid the Michelin tire controversy that limited starters to six Bridgestone-shod cars, from which BAR did not participate), fourth in France on July 3, and fifth in Great Britain on July 10. Sato's results were less consistent, including retirements and lower points finishes. This reliability enabled Button's breakthrough podium of the post-ban period, a third place at the German Grand Prix on July 24 at Hockenheim, where he capitalized on a strong strategy to hold off challengers.[31][32] Further solid performances followed, including points in Hungary and Turkey, before Button claimed his second mid-season podium with third place at the Belgian Grand Prix on September 11 at Spa-Francorchamps, benefiting from a rain-affected race that played to the 007's handling strengths.[31] These results, per Honda's assessment, reflected the team gaining momentum mid-season after early setbacks, with Button amassing 27 points from rounds 7 through 16.[1] Sato added minimal contributions, totaling 4 points in the period. The podiums underscored the 007's aerodynamic efficiency and Honda engine reliability in varied conditions, positioning BAR competitively despite the earlier scandal's impact.[1]Post-Ban Recovery and Season Finale
Following the FIA's imposition of a two-race ban after the San Marino Grand Prix disqualification on April 24, 2005, BAR-Honda returned at the European Grand Prix at the Nürburgring on May 29, 2005. The team had modified the BAR 007's fuel system and added ballast to comply strictly with minimum weight regulations, which initially compromised the car's competitiveness, resulting in no points for either driver.[1] In the Canadian Grand Prix on June 12, 2005, Jenson Button qualified on pole position—his first in Formula One since the 2003 Malaysian Grand Prix—but retired on the first lap after colliding with teammate Takuma Sato, who also failed to finish; the team scored zero points.[1] The United States Grand Prix on June 19, 2005, presented unique circumstances due to Michelin tire failures affecting multiple teams; BAR-Honda, running Michelin tires, participated but Sato alone scored points by finishing fourth among the six Bridgestone-shod cars that completed the race, earning 5 points while Button did not classify after minimal laps. This marked the team's first points post-ban.[33] Subsequent races showed progressive recovery through setup optimizations and reliability improvements. Button finished fourth at the French Grand Prix on July 3, 2005, netting 5 points, followed by a fifth-place result at the British Grand Prix on July 10 (4 points) and a podium third place at the German Grand Prix on July 24 (6 points).[34][35] The season finale at the Brazilian Grand Prix on September 25, 2005, saw Button secure another podium in third position, adding 6 points to his tally, while Sato finished 19th with no points. BAR-Honda concluded the championship sixth in the Constructors' standings with 42 points, reflecting resilience despite the early-season penalties and modifications.[35]Controversies
Imola Weight and Fuel Scandal
At the 2005 San Marino Grand Prix held at Imola on 24 April, BAR-Honda achieved its first podium of the season with Jenson Button finishing third and Takuma Sato fifth, earning the team 10 championship points.[36] Post-race scrutineering focused on Button's BAR 007 chassis, where technical inspectors identified a secondary fuel compartment within the main tank.[4] The team drained fuel from the primary tank, declaring it empty, but FIA technical delegate Jo Bauer noted irregularities, including an estimated 15 liters of undeclared fuel remaining, which raised suspicions of non-compliance with the minimum weight requirement of 605 kg excluding all fuel under Article 4.1 of the 2005 Formula One Technical Regulations.[36] Initial trackside checks cleared the car at the limit, but data analysis suggested the chassis dry weight fell short without the retained fuel, which BAR had incorporated as undeclared ballast to achieve legal mass during inspections.[4] Further examination revealed the BAR 007's fuel system design retained approximately 6 kg of fuel in the secondary compartment, a configuration BAR claimed was essential for engine operation but which the FIA viewed as a deliberate means to circumvent weight rules by effectively using consumable fuel to mask an underweight structure.[4] When fully drained, Button's car weighed 5.4 kg below the limit, confirming the violation.[36] BAR maintained that the regulations did not explicitly require complete fuel evacuation for weighing and that prior homologation tests had not flagged the issue, but the FIA argued this exploited ambiguities for a performance edge, as lighter chassis allow optimized aerodynamics and reduced ballast constraints.[5] The incident prompted an FIA appeal against the Imola stewards' decision, escalating scrutiny on BAR's pre-season weight strategies, where similar undeclared fuel retention had evaded detection in earlier races.[36]FIA Ruling, Appeals, and Aftermath
On May 5, 2005, the FIA International Court of Appeal (ICA) ruled in favor of the FIA's appeal against the stewards' decision to reinstate BAR-Honda's results from the San Marino Grand Prix at Imola on April 24, 2005.[37] The ICA determined that the BAR 007 chassis violated technical regulations, specifically Article 2.6 of the 2005 Formula One Technical Regulations, which required teams to ensure vehicles could be fully drained of fuel during post-race scrutineering without disassembly.[37] Evidence presented showed that approximately 0.8 liters of fuel remained trapped in the car's fuel system baffles after standard draining procedures, causing the vehicles—driven by Jenson Button (initially classified third) and Takuma Sato (seventh)—to fall below the 605 kg minimum weight limit.[5] The court rejected BAR's defense that the residual fuel was incidental and not intentionally concealed, noting the team's failure to disclose the system's limitations during pre-race declarations.[37] Penalties imposed included disqualification of both cars' Imola results, a €500,000 fine (with €250,000 suspended provided no further violations), exclusion from the next two World Championship events (the Spanish Grand Prix on May 8 and Monaco Grand Prix on May 22), and a suspended six-month ban from all remaining 2005 events conditional on future compliance.[5][38] FIA President Max Mosley described the sanctions as "lenient," arguing that BAR's actions undermined the sport's integrity by potentially allowing weight manipulation via undeclared fuel retention.[38] BAR-Honda immediately sought an emergency injunction from a French court to overturn the ban and compete in the Spanish Grand Prix, but the request was denied on May 6, 2005, forcing the team to miss the event.[39] The team accepted the ICA verdict without further appeal, citing the need to focus on compliance and development, and returned at the Canadian Grand Prix on June 12, 2005.[40] The ban resulted in BAR forfeiting potential points from two races, exacerbating their mid-season deficit; Button, who lost six points from his Imola podium, managed only sporadic recoveries thereafter, with the team ultimately finishing sixth in the Constructors' Championship with 38 points.[41] Internally, the scandal prompted technical restructuring, including enhanced fuel system transparency for subsequent scrutineering, though it strained relations with Honda and contributed to leadership changes, such as the departure of technical director Tim Holloway later in 2005.[42] The episode highlighted FIA enforcement inconsistencies, as rival teams like McLaren had faced lighter penalties for similar weight issues in prior years, fueling debates on regulatory equity.[43]Perspectives from Team, Drivers, and Regulators
BAR-Honda team officials defended the BAR 007's fuel system design, asserting that the secondary compartment functioned as a legitimate fuel trap to prevent starvation during high lateral G-forces, rather than a concealed tank for ballast or deception.[44] They maintained that post-race draining procedures at Imola complied with scrutineer instructions, which targeted the main tank only, and argued that FIA stewards had been informed of the design during pre-season technical briefings in March 2005.[45] Team management, including principal David Richards, described the FIA's judgment as "fundamentally flawed" and expressed intent to appeal, emphasizing that the car met minimum weight requirements during actual operation and that no rule explicitly prohibited residual fuel in such traps.[36] Jenson Button, the lead driver, voiced frustration over the disqualification from his third-place Imola finish but distanced himself from technical decisions, stating he was unaware of the specifics and focused on performance rather than engineering disputes.[5] Takuma Sato, who lost fifth place in the same race, echoed support for the team's appeal process without commenting extensively on the design, prioritizing a return to competition after the ban.[5] FIA president Max Mosley characterized the BAR 007's setup as a "crude" and "primitive" deliberate breach intended to mislead scrutineers by retaining undeclared fuel post-draining, violating Article 2c of the technical regulations prohibiting fuel use as ballast.[46] He revealed pre-season suspicions based on BAR's rapid performance gains and wind tunnel data, arguing the two-race ban—upheld on May 5, 2005—was lenient compared to potential exclusion from the championship, as the offense undermined the sport's integrity.[47] Mosley emphasized that the design's intent to evade weight checks justified the penalty, dismissing BAR's fuel trap claim as inconsistent with observed residual volumes exceeding typical safety margins.[38]Variants and Modifications
BAR 007B Updates
The BAR 007B was a modified variant of the BAR 007 chassis adapted during the 2005-2006 off-season to evaluate Honda's RA806E V8 engine, introduced to comply with the Formula One regulation mandating a switch from V10 to V8 power units starting in 2006.[48][49] This adaptation occurred after Honda acquired full ownership of the BAR team in December 2005, rebranding it as Honda Racing F1 Team for the following season.[50] Key modifications centered on integrating the RA806E, a 2.4-liter V8 with reduced dimensions compared to the preceding RA005E V10: it featured a lower physical profile and shorter length, necessitating adjustments to the engine mounting, rear chassis structure, and ancillary systems such as exhaust routing and cooling to maintain balance and aerodynamics.[51] The V8 produced approximately 750-800 horsepower at lower peak revs (around 19,000 rpm versus the V10's higher limits), requiring tuning of the gearbox, clutch, and differential to handle the altered torque delivery and power curve.[52] No major aerodynamic or suspension overhauls were reported, preserving much of the 007's core design for reliability in testing rather than outright performance optimization. Testing was conducted primarily at European circuits including Jerez and Paul Ricard, with BAR-Honda test driver Anthony Davidson logging the majority of mileage to assess engine durability, integration issues, and baseline setup data ahead of the RA106 chassis debut.[48][50] These sessions, spanning late 2005 into early 2006, focused on reliability under race-like loads, identifying early challenges such as vibration management and thermal efficiency inherent to the narrower V8 architecture. The 007B did not compete in Grand Prix events, serving solely as a development mule to accelerate Honda's transition to V8 technology, which proved foundational for their competitive resurgence in 2006.[49]Post-Season Adaptations for Records
Following the conclusion of the 2005 Formula One season, BAR-Honda modified a BAR 007 chassis for the "Bonneville 400" project, aimed at achieving a land speed record for a vehicle compliant with FIA Formula One technical regulations at the Bonneville Salt Flats in Utah. The adaptations were designed to minimize regulatory deviations while optimizing straight-line performance, ensuring the car retained its status as a "track-legal" F1 machine capable of qualifying for official records.[53][54] Key changes included the replacement of the standard rear wing with an upright rear fin to improve high-speed directional stability, as team engineers identified potential aerodynamic instability risks above 350 km/h during wind tunnel simulations and computational fluid dynamics analysis. Additional aerodynamic refinements, such as adjusted bodywork streamlining and reduced drag elements, were implemented following extensive pre-event testing to prioritize top speed over cornering downforce. The Honda RA005E V10 engine remained largely unmodified, producing approximately 780-800 horsepower, paired with the existing semi-automatic sequential gearbox adapted for prolonged high-RPM operation on the salt surface.[55][56][57] Suspension geometry was recalibrated for the flat, low-grip salt terrain, with softer spring rates and revised damper settings to maintain wheel contact during acceleration runs exceeding five miles in length, while tire compounds were selected for durability rather than grip. These post-season alterations, completed by early 2006, transformed the race-spec BAR 007 into a specialized speed vehicle without compromising its core F1 homologation, enabling the record bid scheduled for August 2006.[55][54]Records and Legacy
Speed Record Attempts at Bonneville
Following the 2005 Formula One season, Honda, having taken full ownership of the BAR team, repurposed a modified version of the BAR 007 chassis—redesignated as the Honda RA106—for land speed record attempts under the FIA-sanctioned "Bonneville 400" project.[54] The primary goal was to achieve an average speed exceeding 400 km/h (248.5 mph) over the measured flying mile at the Bonneville Salt Flats in Utah, surpassing the unofficial Formula One top speed benchmark of approximately 369.9 km/h set by a Williams car at Monza in 2004.[58] Modifications included removing the rear wing and replacing it with a vertical stability fin to maintain directional control at high speeds, along with bespoke Michelin tires optimized for the salt surface and minor aerodynamic tweaks to prioritize straight-line velocity over cornering downforce.[54] Prior to the official runs, testing at the Mojave Desert in California yielded a one-way peak of 413.205 km/h (256.8 mph), validating the setup's potential.[59] The Bonneville attempts occurred in July 2006, with South African test driver Alan van der Merwe at the wheel, supported by a small team including engineers and observers from the FIA and land speed record authorities.[60] Early morning sessions were scheduled to minimize thermal expansion of the salt crust and avoid crowds, but variable surface conditions— including patches of slushy, water-affected salt—posed challenges to traction and repeatability.[61] On July 20, 2006, van der Merwe completed two passes over the flying mile, averaging 397.360 km/h (246.908 mph), which was ratified by the FIA as the official land speed record for a Formula One car.[60] [59] One outbound run briefly exceeded 400 km/h at 400.454 km/h, but the return leg fell short due to the compromised salt surface, preventing certification of the higher figure which required bidirectional averaging within a one percent tolerance.[54] This marked the fastest verified two-way average for an F1-speculation vehicle, a record that remains unbroken in its category as of 2025.[59] The effort highlighted the BAR 007's underlying powertrain capabilities, derived from its 2.4-liter V10 engine producing over 900 horsepower, though it underscored limitations imposed by ground-effect aerodynamics and tire technology not optimized for prolonged straight-line runs.[62]Overall Impact on BAR-Honda and Formula One
The BAR 007's promising early-season performance, including podium finishes for Jenson Button at the Australian and Brazilian Grands Prix on March 20 and April 24, 2005, respectively, demonstrated BAR-Honda's potential to challenge for victories following their second-place constructors' finish in 2004. However, the Imola disqualification on April 24, 2005, for operating below the 605 kg minimum weight limit due to an undeclared secondary fuel tank, coupled with a subsequent two-race ban upheld on May 5, 2005, severely disrupted the team's momentum, costing an estimated 20-30 points and relegating them to sixth in the constructors' standings with 38 points. This setback eroded team morale and resources, prompting Honda to acquire full ownership of BAR by late 2005, transitioning the outfit to Honda Racing F1 for 2006 and enabling a rebound to third place in constructors with Button securing his first win at the Hungarian Grand Prix on August 13, 2006.[1] The scandal intensified FIA scrutiny on compliance, leading to the introduction of random post-race weight checks across teams starting in May 2005 to prevent similar fuel-related weight manipulations. It also sparked discussions on clarifying regulations against using fuel as adjustable ballast, with BAR-Honda advocating for explicit rule updates to avoid ambiguities in technical interpretations. While no wholesale regulatory overhaul ensued, the incident contributed to a broader culture of stricter enforcement in an era of tightening cost and tech controls, underscoring vulnerabilities in self-policing amid competitive pressures.[63][64] Post-season, the BAR 007's adaptation for land speed records at Bonneville Salt Flats on July 21, 2006, achieved a Formula One category average of 397.481 km/h (246.983 mph) over the flying mile, driven by Honda test pilot Alan van der Merwe, highlighting the untapped straight-line potential of the Honda RA005E V10 engine producing approximately 900 hp. This endeavor, though failing to officially break 400 km/h due to inconsistent two-way averages required by FIA rules, elevated BAR-Honda's engineering reputation by showcasing F1 technology's versatility beyond circuits and providing promotional value amid the prior controversies. In Formula One's legacy, the BAR 007 exemplified how high-stakes innovation could yield both competitive edges and pitfalls, influencing subsequent Honda efforts until their 2008 withdrawal while reinforcing the sport's emphasis on verifiable compliance over exploitative loopholes.[54][58]Complete Formula One Results
The BAR 007 achieved 38 points in the 2005 Constructors' Championship, securing sixth place overall.[7] Jenson Button amassed 37 of those points across 16 starts, while Takuma Sato contributed 1 point from 15 starts; Anthony Davidson substituted for Sato in the Malaysian Grand Prix due to illness.[34][65] The team was excluded from the Spanish and Monaco Grands Prix following a two-race ban imposed after disqualification from the San Marino Grand Prix for breaching minimum weight regulations.[1]| Grand Prix | Button Position/Points | Sato Position/Points | Notes |
|---|---|---|---|
| Australia | Ret (0) | 14th (0) | Button retired due to mechanical issues after completing laps for classification.[66] |
| Malaysia | Ret (0) | DNS (0) | Davidson substituted for Sato (illness), retired due to engine failure; Button retired due to engine failure.[35] |
| Bahrain | Ret (0) | Ret (0) | Both retired due to mechanical failures (clutch and brakes).[35] |
| San Marino | DSQ (0) | DSQ (0) | Both disqualified post-race for underweight cars; initially classified 3rd and 6th.[35] |
| Spain | EXC (0) | EXC (0) | Team excluded due to FIA ban.[35] |
| Monaco | EXC (0) | EXC (0) | Team excluded due to FIA ban.[35] |
| Europe | 8th (1) | 12th (0) | Return from ban; Button scored via 2005 points system (1 for 8th).[35] |
| Canada | Ret (0) | Ret (0) | Button retired from leading position due to accident; Sato due to brakes.[1] |
| United States | Ret (0) | Ret (0) | Both withdrew pre-race due to tyre safety concerns (Michelin teams).[35] |
| France | 4th (5) | 11th (0) | Button's best non-podium finish.[30] |
| Great Britain | 5th (4) | 16th (0) | -[30] |
| Germany | 3rd (6) | 12th (0) | Button's first podium of season.[32][30] |
| Hungary | 5th (4) | 8th (1) | Sato's sole point.[65] |
| Turkey | 5th (4) | 9th (0) | -[35] |
| Italy | 8th (1) | 16th (0) | -[35] |
| Belgium | 3rd (6) | Ret (0) | Button's second podium; Sato retired from collision.[35] |
| Brazil | 7th (2) | 10th (0) | -[35] |
| Japan | 5th (4) | DSQ (0) | Sato disqualified for dangerous driving post-race.[35] |
| China | 8th (1) | Ret (0) | Sato retired due to gearbox failure.[35] |